Flashback: Spinout

Flashback: Spinout
spinout-kevin-colin-soapbox-derby.jpg

Back in August of 2006, on the pages of MAKE Volume 07, Colin Berry shared the story of his maker brother Kevin Berry and the role that the Soap Box Derby played in his short life. This intimate story moved us all. In October of 2006, Colin read the story as part of our Maker Files series, with an introduction by Dale Dougherty, MAKE’s editor and publisher. Below is Colin’s story in full. To hear him tell the tale, here is the MP3. Or you can get the audio delivered automatically with iTunes.

Spinout
Was building a Soap Box Derby racer my brother’s last best chance at escaping his fate?
By Colin Berry

All his life, my brother Kevin was plagued with terrible luck. It began when he was a teenager in the early 70s, in Longmont, Colorado — our hometown — and soon became something of a family legend. If the Trojan theater was giving away free tickets to Planet of the Apes, the kid in front of Kevin in line would get the last one. If Kevin sold enough newspaper subscriptions to win a clock radio, it was broken when he opened the box. If one of his friends shoplifted a pack of Odd Rods bubblegum cards on the way home from school, Kevin got collared for it. It was a pattern. He weathered it well, half-joking about his luck with his shy, gap-toothed grin, but over time it took a terrible toll.

In shop class, however, Kevin seemed to step out from its shadow. He was adept with tools and proved himself a skilled carpenter at an early age. I was seven years younger and remember marveling at the projects he brought home from junior high school: a varnished gun rack; a Newton’s Cradle, with its five suspended steel balls; a sturdy set of bedroom shelves for his Revell models. Looking back, it follows that the noisy, meditative setting of the woodshop appealed to Kevin. It was a place where no one shouted at him and where no electronic parts could mysteriously fail.

In our basement, Dad had a woodshop, too, a flagstone-floored, fluorescent-lit grotto with an oversized plank workbench, barrels of wood scraps, and tools hung on a pegboard. It was here, from 1969 to 1972, that my brother built four Soap Box Derby racers. He would start in late winter, when snow still covered the ground outside, transforming a small stack of lumber and paper sacks of hardware into a teen-sized, gravity-propelled vehicle.

Balancing the shell of the car across two sawhorses, he built each the same way: a pine plank floorboard supported several plywood bulkheads, to which he anchored Masonite sides and a top. Each car ran on four red-rimmed Soap Box Derby wheels, controlled by a simple cable steering system and foot-pedal drag brake. Each was painted and then lettered with Kevin’s name, number, and sponsor logo (Weicker Moving and Storage). And each one got faster.

spinout-kevin-soapbox-derby.jpg

Despite their similarities, it was the fundamentals that were really the only thing Kevin’s cars had in common. The first two (green and orange) were simple sit-down models; the next two, painted the same bronze color as Weicker’s moving vans, were long, elegant, lie-back cars with a rear headrest that supported my brother’s head. His bright blue eyes were barely visible from beneath the white regulation Derby helmet.

Leaning against the doorway, I am watching him work: the aroma of fresh sawdust mixes with hot electric motor smells of the drill and jigsaw, whiffs of plastic wood, and the rubbery tang of new wheels. The radio segues from Jerry Reed’s “Amos Moses” into Led Zeppelin’s “Immigrant Song”:

We come from the land of the ice and snow
From the midnight sun where the hot springs blow.

And the gentle screek screek of Kevin’s file or keyhole saw drowns out the muffled voices coming from upstairs. He is 14; I am 7. I idolize him, of course, and even though he ignores me as he rasps an axle tree into an aerodynamic shape, he probably secretly enjoys having me down here with him.

After dinner, Dad would look in on him, too, but by then the relationship between the two of them had become tempestuous. With his stoic patience, my father could never — would never — understand Kevin’s propensity for frustration and impulsive anger. A frozen bolt or misdrilled hole could send him into a furious rage, sabotaging many days’ work in a scary tantrum. Generally, he worked alone.

Kevin’s labors were part of a long tradition. Started by Chevrolet in 1934, the All-American Soap Box Derby is known as the “World’s Gravity Grand Prix,” and in my brother’s day, it was open only to boys between 11 and 16 years of age. Its rules were strict. Cars couldn’t exceed 80 inches in length or 250 pounds, including the driver, and materials couldn’t cost more than $40. Contestants built their own cars; parents could offer advice — Kevin could check with Dad on how to laminate the nosepiece or shim the axles (as I did, seven years later) — but the regs specifically forbade adult intervention. Each boy raced in a local competition (ours was in Boulder, on Lehigh Street Hill, around July 4th), and the local winner went to Akron, Ohio, to compete in the national championship. Akron winners received a trophy, a $7,500 college scholarship, and a white champion’s jacket that, if I shut my eyes, I can almost picture Kevin wearing.

Each year, his cars got better. The last — in 1972, when he was 16 — was magnificent. It was a sleek, teardrop-shaped stiletto with meticulously trued wheels, a reverse-hinged rear brake, and a steering system that glided gracefully in its guides. Though his early racers were amateurish and hand-spray-painted, this one was elegant and sophisticated, with steel sleeves for cables, a carpeted floorboard, and four airbrushed coats of copper auto body paint applied inside a newspaper-lined cubicle. Most boys Kevin’s age couldn’t have built it.

At 16, Kevin was heading toward trouble. He already had his learner’s permit and had begun associating with boys who drove real cars, smoked Winstons, and hung out in his attic room, laughing and talking and listening to what would someday be called Classic Rock. Sometimes they would disappear for a while in Carl Kleveno’s blue Duster, returning with red-rimmed eyes and smelling smoky and sweet. Though we never said it out loud, my family and I knew the 1972 Derby marked the end of something, and we convinced ourselves it was Kevin’s last best chance to win.

Race day dawned dry and cloudless. After Dad and Kevin chocked his car carefully into the Fairlane and Mom and my sisters packed tuna sandwiches and a Thermos of milk into the Chevelle, we caravanned to Boulder, securing a spot near the bottom of Lehigh where we could see the finish line. The mood was playful and competitive, as spectators mixed with the young racers.

In his preliminaries, my brother clocked a better time than anyone — more than two seconds faster than the next contender, Bobby Lange, Jr., a rich kid from Boulder with a shiny fiberglass car and cocky attitude. Kevin won his first few heats easily, a copper blur that shot past the finish line, past the checkered flag, and past his sunburned family, who waved and screamed like demons.

“Come on, Kevin!”
“Go! Go! Goooo!”
“Keviiiiiiiiin!”
And the winner is Kevin Berry, Weicker Moving and Storage!

With nearly 30 boys competing, the double-elimination race seemed to last forever. Still, I remember feeling like it was nothing more than a prelude to Kevin’s inevitable victory and, although I wasn’t conscious of it, a lifting of his tainted luck.

Sometime after 3 o’clock, after an endless succession of heats, only six cars remained: Kevin’s, Lange’s, and four others. During one race, as Kevin sped past, I saw something strange happen: just past the finish line, his car pulled suddenly to the left, and, rather than braking normally, swerved and plowed into the hay bales piled at the bottom of the hill. Dad and I dropped our pops and sprinted to him.

Dad got there first. “You all right, Kev?” He sounded worried.

My brother had pulled his helmet off, and his face was sweaty and pale. He was clearly distressed. “I’m OK, but I think the car’s messed up,” he said. “I’m not sure what happened.”

Race officials ran over, pulled bales off the car, and carefully lifted Kevin out. He wasn’t hurt, but as they rolled his car away, its rear wheels made a jarring shudder. Something was wrong.

“Look at that!” Kevin moaned, pointing, and Dad and I looked. Freshly splintered wood protruded from the foam rubber padding where the axle met the body. Somehow his brake had failed, and the crash had torqued the car badly out of alignment.
That was it. Kevin lost his next race by two car lengths, and half an hour later Bobby Lange was the 1972 Boulder champion. I remember riding home in stony silence.

The story could end there — and in a way it did, at least for Kevin. In August, he bought his first real car, a ’61 Buick Special, using money he’d made working at Marcantonio’s Pizza on North Main. Bobby Lange won in Akron, too; the Boulder Daily Camera printed a picture of him, smiling and waving and wearing the white jacket. Kevin’s racer went up on blocks.

We didn’t pay much attention at first, but the next year, 1973, Bobby Lange’s cousin, Jimmy Gronen, also won the Boulder race, and went on to win Akron as well. Yet the officials noticed a strange lurch as Gronen’s car came off the metal starting blocks. They X-rayed it the next day and discovered a powerful electromagnet hidden inside the nose of the car. It was wired to a switch that Gronen’s head activated when he applied pressure to his headrest, and gave him a jump off the line.

The scandal rocked the Derby. Gronen was stripped of his title, and his winnings were given to the runner-up. But the real blame fell on Gronen’s guardian uncle, ski-boot magnate Robert Lange, Sr., Bobby’s father. In legal documents and public statements, the elder Lange took full responsibility for the magnet idea (though not its construction), pointing out with indignation that cheating was endemic to the Derby. At some point, officials asked to X-ray Bobby’s 1972 car, too — the car that had beaten my brother’s — which the DA found during his investigation to have been built with significant engineering expertise and $10,000 to $20,000 worth of equipment. This was clearly in violation of the rules. Though Derby cars are usually preserved for promotional purposes, Bobby’s car was nowhere to be found, and remains so today.

None of this really mattered to Kevin. He was past all that, enmeshed in a teenager’s life filled with the cars, cigarettes, beer, and drugs that kids in the mid-70s suddenly had to contend with. Within two years, Kevin had accumulated a reckless-driving citation, a DUI, a trip to the police station, and a long succession of real cars, some of them wrecked. Like the radio signal from an interplanetary probe that passes behind a planet, his bad luck, which had seemed to disappear for a while, was back, loud and clear.

Kevin barely graduated from high school, and took a series of jobs working for heating contractors until his patience wore thin. He didn’t build much of anything after that — a shingled camper for his pickup, a metal toolbox for Dad — and didn’t seem to have any hobbies. He and I grew distant. His friends seemed to disintegrate into desperation or suicide and, in 1998, he did too, with a .22 pistol in the small, neat bedroom of his trailer on the outskirts of Boulder. He died in January, confessing in his note that he couldn’t stand working outside in the cold anymore.

What would have happened to Kevin if things had unfolded differently on that July day in 1972? How much would have changed? What happened to his brake? Why did it fail? And if it hadn’t, could he have beaten Bobby Lange, even if — and it’s all if, of course — Lange was cheating? Questions pile up like January snow, obfuscating any real truths and forcing those of us who knew Kevin to turn over a thousand times in our minds the ways it might have gone better. In a way, we — his family — are most to blame for the way we perpetuated Kevin’s bad luck in our stories and expectations, allowing it to poke through even as he tried to build something solid against it. Just once, we could have speculated how that long bronze car might have carried him into something better.

Despite the scandal, the Derby has survived, though it’s been altered almost beyond recognition. Cars are built with kits now, and boys and girls from ages 8 to 17 compete, rally-style, in three different divisions. The rules for each comprise a massive PDF file, and kits start at $400 — not including wheels, which cost up to $100 a set.

Even in Kevin’s day, Soap Box Derby wheels were something special. Every year he was issued a new set, and when the car was ready, balancing on its planks, he would slide the new wheels onto their axles, secure the cotter pins, and give them their first long spin. They would whirl for countless minutes, half an hour sometimes, an extended low hiss, like the sound of a distant crowd cheering. There, in the dusty woodshop, it was a sound my brother and I hoped would last forever.

About the Author:

Colin Berry is a journalist, memoirist, and fiction writer. colinberry.com

6 thoughts on “Flashback: Spinout

  1. AP says:

    That was a good story, really well told. I was moved too.

    Those Soap Box races are a culture that we don’t have here, but always appealed to me as a great way to encourage manual hobbies and work. As a kid, I always wished to live in a more “open” space like those American suburbs we watch on TV.

  2. Joey says:

    Wow. Thanks for sharing such a story with us.

    Makes you wonder about the possibilities that each of us has had and what would have happened if things were different in our lives.

    Great story. Definitely makes you think.

  3. djkraz says:

    What an amazing story. I started reading on a conference call and I could not pull myself away from the story. I ended up finishing the story during the call. Anyway, thanks for sharing such a personal and I’m sure emotional story with us!

Comments are closed.

Discuss this article with the rest of the community on our Discord server!
Tagged

I'm a word nerd who loves to geek out on how emerging technology affects the lexicon. I was an editor on the first 40 volumes of MAKE, and I love shining light on the incredible makers in our community. In particular, covering art is my passion — after all, art is the first thing most of us ever made. When not fawning over perfect word choices, I can be found on the nearest mountain, looking for untouched powder fields and ideal alpine lakes.

Contact me at snowgoli@gmail.com or via @snowgoli.

View more articles by Goli Mohammadi

ADVERTISEMENT

Maker Faire Bay Area 2023 - Mare Island, CA

Escape to an island of imagination + innovation as Maker Faire Bay Area returns for its 15th iteration!

Buy Tickets today! SAVE 15% and lock-in your preferred date(s).

FEEDBACK